Surplus electricity production in sugarcane mills using

Surplus electricity production in sugarcane mills using residual bagasse and straw as fuel of steam in the boilers for sugarcane mills with crushing rates of 500 t cane/h. Table 2. Biomass available as fuel for the cogeneration system. out with the parameters of live steam generation of modern bagasse boilers produced nowadays (65 bar

Chat Online

(PDF) Bagasse Dryer Role in the Energy Recovery of Water

A boiler producing 200 t=h of steam Rein.[3]) at 65 bar and 500 C was considered in all the cases. Pursuing the objective of reducing the cost of energy The first law efficiency, based on the HHV of the fuel for recovery system, parametric analyses were made.

Chat Online

Sugarcane | BioEnergy Consult

Apr 29, 2019· During the harvesting operation around 70-80% of the cane trash is left in the field with 20-30% taken to the mill together with the sugarcane stalks as extraneous matter. Cane trashs calorific value is similar to that of bagasse but has an advantage of having lower moisture content, and hence dries more quickly. Nowadays only a small

Chat Online

BAGASSE-FUELLED Cogeneration and COGENERATION

The total investment costs will vary according to boiler pressures and efficiencies selected, and the power plant configurations at different factories. These costs would typically range between $120 million at 60 bar and $230 million at 80 bar, delivering an estimated 480 GWh with simple payback periods of 6-7 years and 8-9 years respectively.

Chat Online

Sugar cane bagasse energy cogeneration - academia.edu

Sugar Cane Bagasse Energy Cogeneration Lessons from Mauritius by Dr Kassiap DEEPCHAND Mauritius Sugar Authority MAURITIUS e-mail: [email protected] Paper Presented to the Parliamentarian Forum on Energy Legislation and Sustainable Development, Cape Town, South Africa (5-7 October 2005) Executive Summary Sugar cane is a major commercially grown agricultural crop

Chat Online

boiler 45 bar Industrial Boiler Supplier

industrial boiler 80 th pressure 45 bar ZOZEN Boiler The boiler produces 8 kg/s of steam at 40 bar and 500 oC. This is expanded to 2 bar with an isentropic efficiency of 0.88. The pump is supplied with feed water at 0.5 bar and 30 oC and delivers it to the boiler at 31 oC and 40 bar. 30 bar 380o C 100 bar 510o C ~ 1 ton Cane 0.65

Chat Online

Techno-economic evaluation of 2nd generation bioethanol

Techno-economic evaluation of 2 nd generation bioethanol production from sugar cane bagasse and leaves bagasse was considered a fluffy waste which was eliminated in low-efficiency 22- bar boilers. The boiler, having an efficiency of 0.80 based on the lower heating value, generates superheated steam at 500°C and 65 bar, which is

Chat Online

COGENERATION A NEW SOURCE OF INCOME FOR SUGAR

Crushing capacity tonnes of cane/hour 500 TCH Crushing capacity tonnes of cane/day 12 000 TCD Effective operation days in one year 180 d/y Crushing capacity tonnes of cane/season 2 160 000 TCS Boiler: steam pressure/temperature 21 bar(g)/ 320°C Fibre % cane 13% Process steam consumption (1.5 bar(g)) 500 kg steam/tc

Chat Online

SUGAR AND ETHANOL INDUSTRIES Energy view

SUGAR AND ETHANOL INDUSTRIES Energy view 24/02/2006 Energy Technology, Stockholm, Sweden 1. 8.5 tons sugar cane Æ2.5 ton bagasse (50% hum) 24/02/2006 Energy Technology, Stockholm, Sweden 5. BAGASSE Increase steam pressure to 80 bars Ægives in a

Chat Online

Cane Sugar Industry Potential and Measures To Reduce

Cane Sugar Industry Potential and Measures To Reduce Sugar Production Cost By Khalid Rashid AL-Moiz Industries unit-II [email protected] ABSTRACT:- The objective of the paper is to evaluate the potentials of sugar industry, it is the only industry which is self sufficient regarding in house requirements except raw material.

Chat Online

Used Boiler Package Water Tube, Used Boilers

70,550#/Hour 565 PSI Walchandnagar Bagasse Fired Bi-Drum Water Tube Boiler. Stock #RG8882. Used bagasse fired bi-drum water tube boiler made by Walchandnagar Industries limited in 1988. Main characteristics as follows: maximum continuous rating is 32 tph (70,550 PPH), peak rating 35.2 tph (77,600 PPH). steam pressure at oultet of main

Chat Online

Comments of stake holders on the discussion paper on

operate at boiler efficiency of 75 to 80%, pressure 60 ksc to 80 ksc and 480 degree centigrade to 500 degree centigrade for which the heat rate are around 4000 kilo Heat rate for off-season:3600 to 3800 k.cal/kwh. Boiler efficiency : On Bagasse 71% On imported Coal 80% Heat rate with Bagasse is 3600 k.cal/unit and boiler efficiency

Chat Online

BestEquip Manual Sugar Cane Juicer 110LBS/H Sugar Cane

Manual Sugar Cane Juicer 110LBS/H 60%-80% Juice Extraction Price Sugar Cane Press Extractor Chrome steel Shell and Inner Rollers This sugar cane press juicer is used to squeeze sugar cane in addition to ginger, apples, sorghum bar, corn stalk and so forth. It is primarily based on loads of analysis and introduct the newest expertise.

Chat Online

BIG - GT AND CEST TECHNOLOGIES FOR SUGAR CANE

BIG - GT AND CEST TECHNOLOGIES FOR SUGAR CANE MILL. THERMODYNAMIC AND ECONOMIC ASSESSMENTS Net boiler efficiency % 80 Steam turbine nominal power MW 20 (29% of bagasse per ton of cane). The trash energy potential was not considered, so the

Chat Online

sugar mill boiler buyers in india Industrial Boiler Supplier

1 min ago sugar mill boiler buyers in india 1 min ago efb generated power plant 1 min ago co2 removing equipment to a coal power plant 1 min ago is there any method for koiler to fertilize without mating 1 min ago power generation

Chat Online

Bagasse | BioEnergy Consult

May 20, 2019· During the harvesting operation around 70-80% of the cane trash is left in the field with 20-30% taken to the mill together with the sugarcane stalks as extraneous matter. Cane trashs calorific value is similar to that of bagasse but has an advantage of having lower moisture content, and hence dries more quickly. Nowadays only a small

Chat Online

Pozzolanic behaviour of a bagasse ash from the boiler of a

PDF | The paper presents a study of the pozzolanic reaction kinetics between calcium hydroxide and sugar cane bagasse ash (SCBAB) from the boiler of a sugar factory. A pozzolanic activity method

Chat Online

Modification of Co-Generation Plant in a Sugar Cane

This study outlines work on the modification of co-generation plant in a sugar cane factory for reduction of power deficit. These modifications, which tested though a sample 6000 TCD sugar cane factory, contain minimization of process steam demand and also high-pressure steam production, using high-pressure boilers which coupled with condensing-extraction steam turbines as option 1 and

Chat Online

bagasse fired boiler pdf - umaexport.co.in

There are two Heat Input in fuel Various Heat losses in types of biomass can be produced from sugar cane, Cane = 100 boiler Trash and bagasse. Cane Trash is the field residue remaining after harvesting the Cane stalk, and bagasse is the fibrous 1. Biomass-Fired Boiler Designed to suit Bagasse, Palm waste, Up to 80 Up To 500. More details

Chat Online

BIG - GT AND CEST TECHNOLOGIES FOR SUGAR CANE

BIG - GT AND CEST TECHNOLOGIES FOR SUGAR CANE MILL. THERMODYNAMIC AND ECONOMIC ASSESSMENTS Net boiler efficiency % 80 Steam turbine nominal power MW 20 (29% of bagasse per ton of cane). The trash energy potential was not considered, so the

Chat Online